Connect with us

Alternative Fuels

Green Ray Project publishes report on methane slip from LNG-fuelled engines

Report focused on collecting information on methane emissions that originate when unburned methane exits the ship engines; use of LNG as maritime fuel has increased but is still marginal.

Admin

Published

on

post 56184

Green Ray Project recently released a comprehensive report with its partner research and technology company VTT Technical Research Centre of Finland Ltd on methane slip from liquefied natural gas (LNG) engines.

The report focused on collecting information on the methane emissions that originate when unburned methane exits the ship engines. 

“Methane slip reduction has been recognised as a topic for engine manufacturers for over 10 years and mitigation of methane slip is enabled both by developing engine technology, after-treatment technologies as well as vessel specific systemic solutions,” according to the report. 

“However, numerical data of methane slip from marine engines in the literature is scarce, especially for the engines built in recent years, posing a challenge for the estimation of total methane slip emissions from shipping today and constructing scenarios for the future.”

“The aim of this work is to provide an overview of the published methane slip emission factors as well as to complement the existing values by collecting ship owner data covering measurements conducted on newly built engines (years 2019-2022).”

In conclusion, the report said use of liquefied natural gas as maritime fuel has increased but is still marginal: less than 3% of ships that reported to the EU MRV in 2021 had a carbon factor less than 3.0, which is an indication of alternative fuel use and most likely LNG. 

The share of LNG of total annual fuel combusted on board ships was 5.9% in 2021 according to the IMO DCS. Methane will be part of future EU mechanisms to cut GHG emissions and mitigation of methane slip is needed to sustain the interest towards the use of LNG as marine fuel.

Note: The full report ‘Review of Methane Slip from LNG Engines’ can be found here.  

 

Photo credit: Green Ray Project
Published: 5 May, 2023

Continue Reading

Newbuilding

Singapore: Pinnacle Marine’s first B100 fuelled utility boat starts 1,000-hour research trial

Newbuilding operated by Prestige Ocean Pte Ltd will capture data on bunker fuel emissions, marine fuel behaviour, and performance.

Admin

Published

on

By

President MT

The 50th vessel constructed by local boat builder Pinnacle Marine (Singapore) Pte Ltd, namely President 100, is starting 1,000 hours of real-time research trials in collaboration with several parties from Wednesday (9 July) onwards, it says.

Powered by B100 biodiesel, the newbuilding operated by Prestige Ocean Pte Ltd will capture data on bunker fuel emissions, marine fuel behaviour, and performance.

It will be participating in trials with Maritime Energy & Sustainable Development Centre of Excellence (MESD), Weichai Singapore, China Classification Society, Pacific International Lines (PTE) Ltd, Abo Shoten, Ltd. / 株式会社安保商店 , Abo Singapore, Wilmar International, Gulf Marine, Amspec Testing & Services, and AYK Engineering and Consulting.

President MT 02

The President 100, Pinnacle Marine’s first full biodiesel utility boat, was launched on Tuesday in the presence of over 100 guests.

“Our latest vessel, President 100, merges legacy and future. Named after our first aluminium boat (“President”) and inspired by B100 biodiesel, it leads the charge for our next 50 vessels — many of which will embrace green technology,” stated Pinnacle Marine in a LinkedIn post.

“The launch was amazing, with strong turnout from across the maritime sector — authorities, shipowners, operators, agencies, chandlers, researchers, offshore engineers, and petrochemical suppliers.”

It added: “We’re excited to see how it paves the way for wider adoption of B100 biodiesel — a cleaner, sustainable path for Singapore’s harbour craft sector.”

 

Photo credit: Pinnacle Marine (Singapore) Pte Ltd
Published: 9 July 2025

Continue Reading

Newbuilding

BHP awards charter contracts for two ammonia dual-fuelled bulk carriers

BHP continues to work with the maritime industry to develop an ammonia bunkering plan for the two vessels when they are delivered from 2028.

Admin

Published

on

By

BHP ammonia DF charters

Global resources company BHP on Wednesday (2 July) signed contracts with COSCO Shipping Bulk Co., Ltd., a subsidiary of COSCO shipping Group (COSCO Shipping) for the charter of two ammonia dual-fuelled Newcastlemax bulk carriers.

The new vessels to be built under this arrangement will be two of only a handful of vessels in the world capable of using ammonia as a bunker fuel.

The two vessels, expected to be delivered from 2028, will primarily transport iron ore from Western Australia to Northeast Asia.

When run on lower or low to zero greenhouse gas (GHG) emissions ammonia, these vessels will be capable of reducing GHG emissions by at least 50% and up to 95% on a per voyage basis compared to a conventionally fuelled voyage.

The five-year time charter contracts are expected to contribute towards a reduction in the GHG emissions intensity of BHP chartered shipping.

BHP continues to work with the maritime industry to develop an ammonia bunkering plan – the process of fuelling ships with ammonia – for the two vessels when they are delivered from 2028.

Sourcing lower and low to zero GHG emissions ammonia is subject to an ongoing tender process.

 

Photo credit: BHP
Published: 9 July 2025

Continue Reading

Milestone

China: Chimbusco and BJEC enter green methanol cooperation agreement

Document was signed between Ding Lihai, deputy general manager of Chimbusco, and Li Jianjun, deputy general manager of BJEC.

Admin

Published

on

By

Chimbusco x BJEC MT

China Marine Bunker (PetroChina) Co.,Ltd. (Chimbusco) and POWERCHINA Beijing Engineering Corporation Limited (BJEC) on Thursday (3 July) formally entered into a green methanol strategic cooperation framework agreement.

The document was signed between Ding Lihai, deputy general manager of Chimbusco, and Li Jianjun, deputy general manager of BJEC.

BJEC, a subsidiary of China Power Engineering Group, is experienced in the survey, design, construction and technology research and development of large-scale renewable energy projects.

Moving forward, the two parties said they will respectively focus on their core advantages and work together to promote the production, supply, storage and refuelling of green methanol as an energy source to help support the low-carbon transformation of the shipping industry.

Ding Lihai said: “The shipping industry is one of the important sources of global carbon emissions. Promoting low-carbon fuel is the key to the transformation of the industry. As the main force in the supply of bunker fuel, Chimbusco has been committed to expanding its clean fuel supply capacity. The cooperation with BJEC will integrate the advantages of green energy development and fuel supply, accelerate the large-scale application of green methanol, and meet the needs of shipping companies for clean fuel. We look forward to providing effective solutions for the green transformation of the shipping industry through the joint efforts of both parties.”

Li Jianjun said: “Implementing the ‘dual carbon’ goal is an important responsibility of enterprises. BJEC has accumulated strong technical strength in the field of green energy. This cooperation with Chimbusco will focus on the entire industrial chain of green methanol, from raw materials, production to supply, to provide clean and sustainable fuel solutions for the shipping industry. The complementary advantages of both parties will promote the rapid development of the green methanol industry and inject strong impetus into the low-carbon transformation of the shipping industry.”

 

Photo credit: China Marine Bunker (PetroChina) Co.,Ltd.
Published: 8 July 2025

Continue Reading

Trending